Gemini cationic surfactants are compounds which are composed of two hydrophilic head groups and two hydrophobic tails linked by a spacer at the head groups or closed to them. The spacer can be either hydrophobic or hydrophilic. It can be rigid or flexible. The neutral charge of the molecule is retained by the presence of organic or inorganic counterions. Critical micelle concentrations (CMCs), surface tension (γ) and minimal inhibitory concentration (MIC) are dozen times lower than corresponding parameters of monomeric surfactants. The unique properties of gemini surfactants with a wide range of hydrophiliclipophilic balance (HLB) make them a very useful, innovative material in detergents, cosmetics, personal care products, additives for paints and coatings, biocides, material science, organic synthesis, pharmacy, textiles, enhanced oil recovery, nanotechnology, petroleum and many other branches of life. A large number of papers concerning gemini surfactants have been published so far. This review presents a synthetic look at current work devoted to structure, synthesis and applications of gemini surfactants.

Aerobic biodegradability and aquatic toxicity of five types of quaternary ammonium-based gemini surfactants have been examined. The effect of the spacer structure and the head group polarity on the ecological properties of a series of dimeric dodecyl ammonium surfactants has been investigated. Standard tests for ready biodegradability assessment (OECD 310) were conducted for C12 alkyl chain gemini surfactants containing oxygen, nitrogen or a benzene ring in the spacer linkage and/or a hydroxyethyl group attached to the nitrogen atom of the head groups. According to the results obtained, the gemini surfactants examined cannot be considered as readily biodegradable compounds. The negligible biotransformation of the gemini surfactants under the standard biodegradation test conditions was found to be due to their toxic effects on the microbial population responsible for aerobic biodegradation. Aquatic toxicity of gemini surfactants was evaluated against Daphnia magna. The acute toxicity values to Daphnia magna, IC50 at 48 h exposure, ranged from 0.6 to 1 mg/L. On the basis of these values, the gemini surfactants tested should be classified as toxic or very toxic to the aquatic environment. However, the dimeric quaternary ammonium-based surfactants examined result to be less toxic than their corresponding monomeric analogs. Nevertheless the aquatic toxicity of these gemini surfactants can be reduced by increasing the molecule hydrophilicity by adding a heteroatom to the spacer or a hydroxyethyl group to the polar head groups.

Hexamethylene-1,6-bis-(N,N-dimethyl-N-dodecylammonium bromide) (1), pentamethylene-1,5-bis(N,N-dimethyl-N-dodecylammonium bromide) (2), tetramethylene-1,4-bis(N,N-dimethyl-N-dodecylammonium bromide) (3), trimethylene-1,3-bis(N,N-dimethyl-N-dodecylammonium bromide) (4) and ethylene-1,2-bis(N,N-dimethyl-N-dodecylammonium bromide) (5) have been obtained and characterized by FTIR and NMR spectroscopy. DFT calculations have also been carried out. The optimized bond lengths, bond angles and torsion angles calculated by Hartree-Fock/3-21G(d,p) approach have been presented. MIC values for A. niger, P. chrysogenum, C. albicans have been determined and the relationship between MIC and spacer length has been discussed.

Series of quaternary ammonium-based gemini surfactants with long alkyl chains (C12 and C18) containing different spacers and substituents attached to the polar head group have been synthesized and their aggregation properties in aqueous solution examined. The effect of the hydrophobic chain, the nature and structure of the spacer group and the polarity of the head group on the aggregation behavior of such dimeric surfactants has been investigated. The critical micelle concentration (cmc) values of gemini surfactants in aqueous solution were determined by conductivity, steady state fluorescence and potentiometric measurements. The size of aggregates formed by investigated amphiphiles above the cmc in aqueous solution was examined by dynamic light scattering. Gemini surfactants show cmc values significantly lower than those of comparable single chain surfactants. The tendency of trimeric surfactants with a rigid spacer to form aggregates is higher than that of the corresponding dimeric surfactants. As occurs for monomeric ionic surfactants, the cmc of gemini surfactants decreases with the elongation of the hydrophobic chain. However, the effect of lengthening the alkyl chain on the cmc depends on the structure of the spacer. C12 gemini surfactants with a rigid hydrophobic spacer exhibit cmc higher than those containing a flexible hydrophobic spacer. For gemini surfactants with C18 alkyl chains this effect is even more pronounced and leads to differences in cmc values greater than one order of magnitude. The structure of the spacer, flexible or rigid chain, has been found to be a critical parameter on the self-assembly of long chain gemini surfactants. Spherical micelles are spontaneously formed above the cmc for C12 gemini surfactants, whereas trimeric and C18 gemini surfactants seems to form vesicle-like aggregates when self-aggregation occurs.

No abstract